Bagasse is the fibrous and pithy material remaining after the sugar containing juice has been crushed and squeezed from the sugarcane. Raw sugar is obtained from this juice in a process involving clarification, concentration and crystallization, and each of these steps requires energy, usually in the form of low pressure steam. The bagasse biomass boiler produced by CBM can effectively use bagasse and produce steam for sugar production. The energy saving and emission reduction benefits of sugarcane baggage boiler power generation are also very obvious.

Steam boiler safety valve Di installation and adjustment of safety valves for cara cepat agar steam boiler cepat naiks, the importance of self-evident purpose is to protect the safe operation of steam boilers Di, when the medium pressure in the steam boiler or pipe rises, exceeds the specified value automatically open, steam boiler safety shutdown. Safety valve so important, then for Di install it, what should What precautions do, the author based on years of experience, special summarized below. A safety valve safety valve should be installed after Di hydrostatic test boiler installation is complete, should be adjusted safety valve operating pressure during the initial Stoke. Adjusted in accordance with the National Labor Safety Technical Supervision Regulation Administration steam boiler 143 Table 7-2 a predetermined pressure. Second, adjusting the opening of the safety valve remove the pin, removing the top cover, loosen the hexagon nuts and screwing the adjustment screw, to relax or tighten the spring to achieve the required exhaust pressure relief valve. After adjusting tighten the lock nut, and then the remaining parts installed properly. When the valve reaches the predetermined setting pressure should seal, valve unless verify, at any other time does not allow unauthorized disassembly seals. First, when adjusting the safety valve, the water level in the drum should be slightly lower than normal water levels, and water ready at any time after the safety valve can open. Secondly, do not striking any part of the safety valve, the safety valve can only open the lever on the valve. Finally, in the former boiler safety valve is not adjusted absolutely prohibited.

Exhaust gas has been plagued by sewage paper industry, paper industry pollution problems of the country very seriously. Fujian Heng paper packaging company has been committed to the use of clean-type boiler paper processing. October 22, 2016, David Carse, the paper with my company, signed a 6 tons of steam an integral condensing cara cepat agar steam boiler cepat naik for the production of corrugated cardboard and other paper products. I provided the boiler greatly solve the problem of sewage wastewater Heng paper. After the boiler operation, both to meet local environmental requirements, but also reduce operating costs for the constant boiler paper products.

There are reasons szs gas boiler regular maintenance of the gas boiler which szs requirements for water quality in relation to other forms of boiler water quality is much higher operating efficiency szs gas boilers, boiler service life is an important reference customers to buy index. Of course, this is a preliminary issue, linked to the quality of the boiler, but after the operation and maintenance of the real needs of customers insist on a regular basis to complete. 1, differences in the quality of gas and liquefied petroleum gas (LPG) is a relatively pure source of gas, the gas is relatively poor artificially, impurities, unstable ingredients, low heat value, has a great influence on the operation and life of the equipment. 2, China's large land area differences in water quality, water quality big difference. Water calcium and magnesium ions of different contents. Although the boiler water is demineralized water after treatment, but difficult to scale, but only reduce the water softening Calcium and magnesium ions can not be completely eliminated. Heated water, water, calcium, magnesium, iron carbonate with water, silicates and hydroxides rapidly, forming calcium carbonate, magnesium silicate fouling, firmly attached to the heat exchanger and piping on the inner wall. The results show that the heat transfer performance of the system deteriorates to reduce the diameter, the flow is blocked, the energy consumption increases. Once the water flow is blocked, boiler pump failure occurs, the main heat exchanger are easily damaged at a high temperature flame.